R22 helicopter’s collision with terrain highlights risks of low-level flying


R22 accident site

A Robinson R22 helicopter collided with terrain when it likely encountered a downdraft with insufficient height to recover while unnecessarily flying at low level through the Northern Territory’s MacDonnell Ranges, an ATSB investigation has found.

The R22 had departed a cattle station’s homestead’s helipad to inspect bore sites and then assist with the recovery of a vehicle at Quartz Hill. After completing a bore inspection, the helicopter took-off and was levelled off at 150 feet above ground level, which was below the peaks of the surrounding terrain as it tracked into the MacDonnell Ranges to continue towards Quartz Hill.

Shortly after entering the MacDonnell Ranges, the R22 collided with the ground on a downslope, about 125 kilometres east of Alice Springs. The helicopter’s last recorded data point indicated it was at about 142 feet above ground level with an estimated ground speed of about 79 knots. The pilot sustained fatal injuries and the passenger was seriously injured.

Even if a pilot has been trained and approved to conduct low-level operations it should be avoided when there is no operational need to do so.

ATSB analysis of the helicopter’s GPS data and other available evidence suggested the pilot was likely operating the helicopter at low-level and possibly contour flying. For the prevailing winds, the helicopter’s final track placed it on the lee side of higher ground. Bureau of Meteorology anaylsis indicated that broadscale moderate turbulence was especially likely at the time of the accident in the lee of the ranges and as a result of stronger upper winds mixing with lower winds.

ATSB Director Transport Safety Dr Godley said the investigation determined it was very likely the pilot was operating at low-level when the helicopter encountered a downdraft with insufficient height to recover, leading to the collision with terrain.

“When flying at low altitude there is a lower margin for error for obstacle avoidance. Even if a pilot has been trained and approved to conduct low-level operations it should be avoided when there is no operational need to do so,” Dr Godley said.

The investigation also found a number of other factors that increased risk, including incomplete pre-flight planning, overloading, a forward centre-of-gravity, and the pilot’s elevated blood alcohol level.

“Examination of the pilot’s iPad and iPhone found it was unlikely that flight planning data, such as meteorological information, had been accessed in the lead-up to the flight,” Dr Godley said.

“Thorough pre-flight planning is essential for avoiding hazardous weather conditions. It is not only important to obtain the relevant weather information to develop a mental picture of the conditions that may be encountered, but also to assess and understand how it relates to the planned flight.”

The investigation report also notes that it was very likely that the helicopter was overweight on departure and its centre-of-gravity was beyond the forward limit for the entire flight.

“Weight and balance have the potential to influence aircraft handling characteristics, and so it is critical that the loading remains within the prescribed operating limits for the entire flight,” Dr Godley said. “Otherwise, as the safety margin steadily erodes, even an experienced pilot may not be able to recover from a rapidly developing unsafe condition.”

The report also notes that alcohol was also present in the pilot’s blood at a level capable of impairing performance. However, evidence of previous low flying suggested the pilot’s actions may have been normal behaviour and not influenced by alcohol. Therefore, the investigation could not conclude that the pilot’s elevated level of alcohol contributed to the accident, but considered that it increased the likelihood of risk-taking behaviour and mishandling the helicopter in an emergency.

“This accident is an important reminder that blood alcohol can persist the day after significant alcohol consumption, and the residual effects of alcohol may impair performance, especially in demanding situations,” Dr Godley said.

You can find here the investigation report: AO-2018-077: Collision with terrain involving Robinson R22 Beta II, VH-KZV, 125km ENE of Alice Springs, Northern Territory, on 24 November 2018

/Public Release. The material in this public release comes from the originating organization and may be of a point-in-time nature, edited for clarity, style and length. View in full here.